具有隐藏故障的多状态竞争失效系统检测策略研究

doi:10.16381/j.cnki.issn1003-207x.2021.1175

中国管理科学 ›› 2021, Vol. 29 ›› Issue (12): 237-248.doi: 10.16381/j.cnki.issn1003-207x.2021.1175

• 论文 • 上一篇

具有隐藏故障的多状态竞争失效系统检测策略研究

张延静¹, 马义中², 沈静远², 刘丽君², 孟晓华¹

1.苏州大学政治与公共管理学院，江苏苏州215123； 2.南京理工大学经济管理学院，江苏南京210094

收稿日期:2021-06-11 修回日期:2021-11-08 出版日期:2021-12-20 发布日期:2021-12-28
通讯作者: 孟晓华（1976-），男（汉族），江苏滨海人，苏州大学政治与公共管理学院，教授，博士，博士生导师，研究方向：数理统计与管理、环境创新与战略，Email:mengxhsuda@163.com. E-mail:mengxhsuda@163.com
基金资助:
国家自然科学基金资助项目(71931006，71872088，71801128，72174136)

Inspection Strategy for a Multi-state Competing Failure System with Hidden Failures

ZHANG Yan-jing¹, MA Yi-zhong², SHEN Jing-yuan², LIU Li-jun², MENG Xiao-hua¹

1. School of Politics and Public Administration, Soochow University, Suzhou 215123, China; 2. School of Economics and Management, Nanjing University of Science and Technology, Nanjing 210094, China

Received:2021-06-11 Revised:2021-11-08 Online:2021-12-20 Published:2021-12-28
Contact: 孟晓华 E-mail:mengxhsuda@163.com

摘要/Abstract

摘要： 复杂工业系统的故障中有40%属于隐藏故障，若隐藏故障得不到及时消除，则可能导致巨大的经济损失。本文针对具有隐藏故障的多状态竞争失效系统，在考虑不完全检测的基础上，对其进行了维修建模。首先，基于制定的视情维修策略，分析了系统的更新情形；然后，基于所推导出的各种系统更新情形的发生概率，建立了以期望成本率为目标函数，以检测间隔时间为决策变量的维修模型。最后，以电容器组为例对所构建维修模型的适用性和有效性进行了验证，研究结果表明，检测质量对检测策略的制定有重要影响，因此研究具有隐藏故障的多状态竞争失效系统的检测策略时，有必要考虑检测误差。本文提出的维修建模方法不仅能在一定程度上丰富多状态竞争失效系统的维修策略理论与方法，还能为工程实际中复杂工业系统的维修工作提供理论基础与决策依据。

关键词: 隐藏故障；多状态竞争失效系统；不完全检测；视情维修

Abstract: 40% of all failure modes of complex industrial systems fall into the category of hidden failures. It is likely to cause huge economic losses if these hidden failures are not eliminated in time. In this paper, the maintenance strategy problem of a multi-state competing failure system with hidden failures is studied by considering imperfect inspection. Firstly, all the renewal scenarios of the system are analyzed according to the given condition-based maintenance strategy. Then, the occurrence possibility of each renewal scenario is derived, based on which the maintenance model is established. The constructed maintenance model takes the expected cost rate as the objective and the inspection interval as the optimization variable. Finally, a capacitor bank is taken as an example to verify the applicability and effectiveness of the proposed maintenance model. The results show that inspection quality has an important influence on the decision-making of the inspection strategy. Therefore, inspection errors should be considered when constructing maintenance model. The modeling method proposed in this paper can not only enrich the maintenance strategy theory and method of multi-state competing failure systems to a certain extent, but also provide theoretical basis and decision-making basis for the maintenance of complex industrial systems in engineering practice.

Key words: hidden failure;multi-state competing failure system; imperfect inspection; condition-based maintenance

中图分类号:

TH165+.3

张延静, 马义中, 沈静远, 刘丽君, 孟晓华. 具有隐藏故障的多状态竞争失效系统检测策略研究[J]. 中国管理科学, 2021, 29(12): 237-248.

ZHANG Yan-jing, MA Yi-zhong, SHEN Jing-yuan, LIU Li-jun, MENG Xiao-hua. Inspection Strategy for a Multi-state Competing Failure System with Hidden Failures[J]. Chinese Journal of Management Science, 2021, 29(12): 237-248.

参考文献

［1］ Moubary J. Reliability-centered maintenance Ⅱ［M］. New York: Industrial Press, 1997.
［2］赵丽莉, 李雪明, 倪明, 等. 继电保护与安全稳定控制系统隐性故障研究综述及展望［J］. 电力系统自动化, 2014, 38(22): 128-135.Zhao Lili, Li Xueming, Ni Ming, et al. Review and prospect of research on hidden failures of protection system and security and stability control system［J］. Automation of Electric Power Systems, 2014, 38(22): 128-135.
［3］ Hu Jiawen, Shen Jingyuan, Shen Lijuan. Opportunistic maintenance for two-component series systems subject to dependent degradation and shock［J］. Reliability Engineering & System Safety, 2020, 201.
［4］ Dong Weijie, Liu Sifeng, Cao Yingsai, et al. Time-based replacement policies for a fault tolerant system subject to degradation and two types of shocks［J］. Quality and Reliability Engineering International, 2020, 36: 2338-2350.
［5］ Song Sanling, Coit D, Feng Qianmei. Reliability for systems of degrading components with distinct component shock sets［J］. Reliability Engineering and System Safety, 2014, 13: 115-124.
［6］赵建印, 刘芳, 孙权, 等. 基于竞争失效模型的金属化膜脉冲电容器产品可靠性研究［J］. 系统工程理论与实践, 2006, 26(1): 60-64.Zhao Jianyin, Liu Fang, Sun Quan, et al. Reliability analysis of metallized-film pulse capacitor under competing failure modes［J］. Systems Engineering-Theory & Practice, 2006, 26(1): 60-64.
［7］庄东辰, 茆诗松. 退化数据统计分析［M］. 北京: 中国统计出版社, 2013.Zhuang Dongchen, Mao Shisong. Statistical analysis of degradation data［M］. Beijing: China Statistics Press, 2013.
［8］陈童, 谢经伟. 面向预防性维修的两种失效竞争下多状态系统可靠性模型［J］. 系统工程理论与实践, 2020, 40(3): 807-816.Chen Tong, Xie Jingwei. Reliability analysis of multi-state system with competing failure based on preventive maintenance［J］. Systems Engineering-Theory & Practice, 2020, 40(3): 807-816.
［9］张英芝, 牛序磊, 申桂香, 等. 基于竞争失效模式的数控机床可靠性建模［J］. 系统工程理论与实践, 2014, 34(8): 2144-2148.Zhang Yingzhi, Niu Xulei, Shen Guixiang, et al. Numerically-controlled machine reliability modeling based on competing failure mode［J］. Systems Engineering-Theory & Practice, 2014, 34(8): 2144-2148.
［10］ Sabri-Laghaie K, Noorossana R. Reliability and maintenance models for a competing-risk system subjected to random usage［J］. IEEE Transactions on Reliability, 2016, 65(3): 1271-1283.
［11］金光. 基于退化的可靠性技术: 模型、方法及应用［M］. 北京: 国防工业出版社, 2014.Jin Guang. Degradation-based reliability technology: Model, method and application［M］. Beijing: National Defence Industry Press, 2014.
［12］ Song Sanling, Coit D, Feng Qianmei, et al. Reliability analysis for multi-component systems subject to multiple dependent competing failure processes［J］. IEEE Transactions on Reliability, 2014, 63(1): 331-345.
［13］ Yousefi N, Coit D, Song Sanling, et al. Optimization of on-condition thresholds for a system of degrading components with competing dependent failure processes［J］. Reliability Engineering & System Safety, 2019, 192.
［14］张延静, 马义中, 欧阳林寒, 等. 基于竞争失效的单部件系统可靠性建模与维修［J］. 系统工程与电子技术, 2017, 39(11): 237-244.Zhang Yanjing, Ma Yizhong, Ouyang Linhan, et al. Reliability modeling and maintenance strategy for a single-unit system based on competing failure processes［J］. Systems Engineering and Electronics, 2017, 39(11): 237-244.
［15］ Cui Lirong, Wu Bei. Extended phase-type models for multistate competing risk systems［J］. Reliability Engineering & System Safety, 2019, 181: 1-16.
［16］ Wang Xiaolin, Jiang Ping, Guo Bo, et al. Real-time reliability evaluation for an individual product based on change-point Gamma and Wiener Process［J］. Quality and Reliability Engineering International, 2014, 30(4): 513-525.
［17］ Yan Weian, Song Baowei, Duan Guilin, et al. Real-time reliability evaluation of two-phase Wiener degradation process［J］. Communications in Statistics-Theory and Methods, 2017, 46: 176-188.
［18］ Alaswad S, Xiang Yisha. A review on condition-based maintenance optimization models for stochastically deteriorating system［J］. Reliability Engineering and System Safety, 2017, 157: 54-63.
［19］ Sarkar B, Saren S. Product inspection policy for an imperfect production system with inspection errors and warranty cost［J］. European Journal of Operational Research, 2015, 248(1): 263-271.
［20］ Yang Li, Ma Xiaobing, Zhao Yu. A condition-based maintenance model for a three-state system subject to degradation and environmental shocks［J］. Computers and Industrial Engineering, 2017, 105: 210-222.
［21］ Zhang Yanjing, Shen Jingyuan, Ma Yizhong. An optimal preventive maintenance policy for a two-stage competing-risk system with hidden failures［J］. Computers and Industrial Engineering, 2021, 154(4): 107135.
［22］ Ross S. Stochastic processes［M］. New York: John Wiley & Sons, 1996.
［23］ Wang Pingping, Tang Yincai, Bae S, et al. Bayesian analysis of two-phase degradation data based on change-point Wiener process［J］. Reliability Engineering & System Safety, 2017, 170: 244-256.
［24］ Christer A, Waller W. Reducing production downtime using delay-time analysis［J］. The Journal of the Operational Research Society, 1984, 35(6): 499-512.
［25］郑睿, 吕文元. 基于时间延迟理论的预防维修模型及案例研究［J］. 中国管理科学, 2010, 18(2): 48-54.Zheng Rui, Lv Wenyuan. Modelling of preventive maintenance based on the delay time theory and case study［J］. Chinese Journal of Management Science, 2010, 18(2): 48-54.
［26］石冠男, 张晓红, 曾建潮, 等. 基于状态空间划分的可修系统视情维修决策［J］. 系统工程理论与实践, 2020, 40(5): 1350-1360.Shi Guannan, Zhang Xiaohong, Zeng Jianchao, et al. Optimal condition-based maintenance decision for repairable systems based on space partition method［J］. Systems Engineering-Theory & Practice, 2020, 40(5): 1350-1360.
［27］ Zhao Xiujie, He Shuguang, He Zhen, et al. Optimal condition-based maintenance policy with delay for systems subject to competing failures under continuous monitoring［J］. Computers and Industrial Engineering, 2018, 124: 535-544.
［28］ Tang Diyin, Yu Jinsong, Chen Xiongzi, et al. An optimal condition-based maintenance policy for a degrading system subject to the competing risks of soft and hard failure［J］. Computers and Industrial Engineering, 2015, 83: 100-110.
［29］ Peng Rui, Liu Bin, Zhai Qingqing, et al. Optimal maintenance strategy for systems with two failure modes［J］. Reliability Engineering and System Safety, 2019, 188, 624-632.
［30］ Yousefi N, Coit D, Zhu Xiaoyan. Dynamic maintenance policy for systems with repairable components subject to mutually dependent competing failure processes［J］. Computers & Industrial Engineering, 2020, 143.
［31］ Williams G, Hirani R. A delay time multi-level on-condition preventive maintenance inspection model based on constant base interval risk-when inspection detects pending failure［J］. International Journal of Machine Tools & Manufacture, 1997, 37(37): 823-836.
［32］ Seyedhosseini S, Moakedi H, Shahanaghi K. Imperfect inspection optimization for a two-component system subject to hidden and two-stage revealed failures over a finite time horizon［J］. Reliability Engineering & System Safety, 2018, 174: 141-156.

具有隐藏故障的多状态竞争失效系统检测策略研究

Inspection Strategy for a Multi-state Competing Failure System with Hidden Failures

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

Metrics

本文评价

推荐阅读 0